Aquaculture equipment factory right now: In the early 21st century, with the rapid development of materials science, new corrosion-resistant, high-strength, and relatively low-cost materials, such as PVC and PE, were widely used in aquaculture facilities and piping systems, greatly improving the durability and stability of these systems. Simultaneously, significant breakthroughs were made in water quality monitoring technology, with the emergence of various high-precision sensors capable of real-time and accurate monitoring of key parameters in aquaculture water, such as temperature, dissolved oxygen, pH, and ammonia nitrogen. Based on this monitoring data, automated control systems became more intelligent, automatically adjusting equipment operation according to changes in water quality, achieving precise control of the aquaculture environment. Furthermore, in the field of aquaculture nutrition and feed technology, in-depth research was conducted on the nutritional needs of different aquaculture species at different growth stages, leading to the development of more precise feed formulations, improving feed utilization, and reducing environmental pollution. During this period, land-based recirculating aquaculture systems (RAS) developed rapidly globally, with Asia, South America, and other regions beginning to vigorously promote and apply this aquaculture model, resulting in a qualitative leap in both scale and technological level.
Flow-rate optimization is an interruption to this dynamic, which causes the hydraulic retention time in each tank or raceway to change. Hydraulic retention time is the time a particle stays in a particular unit before it is forced out (Fan et al., 2023). The shortening of this retention time will allow farms to physically eliminate stages of infective parasites before attaching to fish. The research on monogenean larvae reveals that, they are the most perilous during the initial two hours of their hatching and the infectivity reduces drastically after four to eight hours (Hoai, 2020). In juvenile salmonid or marine finfish systems with retention times in the farms of between thirty and fifty minutes they significantly decrease the likelihood of encountering a host by the larvae. It is an engineering-based solution that is not based on chemicals or biological remedies but rather relies on the velocity of water to exceed the pathogen biological window of infectivity (Morro et al., 2022). When handling highly parasite sensitive species like Atlantic salmon, rainbow trout, cobia, and sea bass, flow-rate manipulation is particularly of particular concern. Discover many more info at aquaculture equipment manufacturer.
Ozone alone cannot maintain a stable RAS environment. Fish release ammonia continuously through their gills and metabolic waste, and even low concentration of ammonia impairs gill function, suppress appetite and inhibit growth. Due to this fact, biological filtration is the second key pillar of the dual-treatment approach. In the biofilter, Nitrosomonas, Nitrobacter and Nitrospira are specific nitrifying bacteria that will turn ammonia to nitrite and subsequently to nitrate via the nitrification process (Oshiki et al., 2022). This bio-chemical conversion is necessary in preserving a safe environment in high-density aquaculture plants. Due to ozone being sensitive to these bacteria, physical separation between ozone contact and biological filtration must be maintained during system design. In contemporary RAS, ozone is sprayed into a separate chamber where it combines with water then flows through a degassing unit that removes all the remaining ozone. This step is only done after which treated water can be admitted into the biological filtration process(Xiao et al., 2019).
To ensure the success of the dual ozone-biofilter system, it is important to maintain the right operation parameters. The values of oxidation-reduction potential in the ozone contact chamber are normally 275 to 320 millivolts (mV). This spectrum aids in efficient reduction of organic matter without generating any undesirable reaction byproducts (Davidson et al., 2021). Before the ozone unit, mechanical drum filters of sixty to one hundred microns in size are used to remove large, suspended solids to enhance ozone efficiency by decreasing the organic load. Optimal values of dissolved organic carbon are four milligrams per liter because beyond this level, the water fails to be clear and promotes the growth of microbes. The concentration of dissolved oxygen below the ozone chamber is usually more than nine milligrams per liter since ozone decomposes naturally to produce oxygen. Having high dissolved oxygen levels greatly improves fish metabolism as well as the rate of nitrification. Most importantly, the amount of residual ozone entering the biofilter should also be zero, this is achieved through constant monitoring to ensure that the nitrifying bacteria is not damaged.
The market demand for seafood in West Africa is both pressing and expanding. Fish is the most widely consumed animal protein across the region, transcending religious, ethnic, and social boundaries, and serves as a cornerstone of food security for millions. In countries like Benin, Ghana, and Senegal, over 50% of the population consumes fish daily, with seafood contributing up to 3-5% of national GDP in key economies. This demand is accelerating due to two defining trends: rapid population growth and increasing health consciousness. West Africa’s current population of 380 million is projected to more than double by 2050, with Nigeria alone expected to reach 440 million people – creating an unprecedented need for affordable, protein-rich food sources. Simultaneously, growing awareness of fish’s nutritional benefits, including omega-3 fatty acids and vitamin D, is driving demand for high-quality, safe seafood. Compounding this, overfishing and poor fishery management have depleted wild stocks, reducing per capita fish consumption and forcing markets to diversify their sources – making aquaculture an essential complement to capture fisheries. Regionally, the Economic Community of West African States (ECOWAS) offers a $623 billion GDP market, with strategic access to European markets via free trade agreements, opening export opportunities beyond local consumption. Discover even more info on wolize.com.
Founded in 2009 and headquartered in Shandong, China, Shandong Wolize Biotechnology Co., Ltd. has spent the last 15 years dedicated to the R&D, manufacturing and global deployment of advanced aquaculture equipment and liquid-storage solutions. Backed by strategic partnerships with five leading Chinese universities – including Ocean University of China and Shanghai Ocean University – and certified to ISO 9001, ISO 22000, CE and COA standards, Wolize has delivered projects in 47 countries and regions. To date we have built 22 large-scale facilities, each exceeding 3,000 m³ of water volume, while the fish grown in our systems are now exported to 112 countries worldwide.